-
Very Active Member
Fans running a lot??
.
So here we are, 200 miles from home, at a biker rally in Winnemucca, Nv.
And the fans run a lot.. Checked the coolant level and added maybe 2 cups of water. Didn't Help.
Any thoughts???
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
Very Active Member
Only a thought, lots of bugs in radiators?
Artillery lends dignity to what would
otherwise be a vulgar brawl.
******************************
Cognac 2014 RT-S
-
Very Active Member
.
Checked that also and they are clear. Momorn Crickets are out in droves but a good inspection of the screens and radiator show clear. A bad relay or sensor perhaps??
The fans are not constantly on but more than in the past. I'm puzzled.
The Spyder ran fine and showed NO signs of overheating.
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
Very Active Member
Originally Posted by Lew L
.
Checked that also and they are clear. Momorn Crickets are out in droves but a good inspection of the screens and radiator show clear. A bad relay or sensor perhaps??
The fans are not constantly on but more than in the past. I'm puzzled.
The Spyder ran fine and showed NO signs of overheating.
We both have 2014 RT's .... did you check both sides of the radiators ???? ... also is the CAP tight and secure ???.... Mike
-
Very Active Member
.
Yes and yes. Even checked the oil level properly and as always--- it's where it was 3,500 miles ago
Maybe I'm just being a worry wart but the has been so good ( Perfect) for years this fan situation had me concerned.
Thanks for nor responses.
Lew L
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
Very Active Member
How about the ambient temp? It has been extremely hot here so early in the season and my temp gauge reads just a bit higher than it has thus far this year and my fans have come on a bit more frequently but not excessively so given the slightly higher temp gauge reading. I too checked the cold coolant level and it was right on the cold line.
Artillery lends dignity to what would
otherwise be a vulgar brawl.
******************************
Cognac 2014 RT-S
-
Very Active Member
.
Ambient temps in low to mid 80s . Took the out later after checking everything and all seemed fine. I just don't know.
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
Very Active Member
-
Very Active Member
You may want to poke around the water pump and see if you have any signs of fluid dripping out the weep hole, just for kicks!! Good luck
-
Very Active Member
-
Were you in stop and go traffic for that to happen?
-
Very Active Member
.
Yes and no. There were times when I could hear the fans at 20 mph???
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
It could happen to have the fans running like that with the temps in the 80's. If it wasn't over heating I wouldn't worry to much about but just keep a eye on it.
Mine turn on while I am riding at times too. More so in slow traffic too.
-
Very Active Member
.
OK, thanks triker . Now for the Ryde home from the Run-a-Mucca rally in Winnamucca Nv. About 200 miles. Leaving early!!
Where is the temp sensor for the fan located??? More for future reference.
Thanks in advance,
Lew L
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
Very Active Member
I am thinking its attached to the fan housing, but I am not sure!!! That's where I have found them before on cars!!
-
Coolant Temperature sensor is on the left side of the engine. Looks like somewhere around the middle of the engine from the picture.
If you have BUDS you can check that to your gauge too and if they match the sensor is probably good.
There is a OHM test of the sensor too.
-
Very Active Member
-
Very Active Member
Good Luck, hope your back on the road soon!!!!!
-
Very Active Member
.
Not soon......... The shop I kinda trust is out 7 weeks for service. Vacation to Pikes Peak and three-wheel rally cancelled!! Oregon ryde with friends cancelled. V-Max is a great back up but not for cross country with my wife.
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
Active Member
After a 30 mile ride on the highway yesterday, my 5 day old Spyder F3 had the fan running as the rig was idling outside my garage. Outside temperature was 12 C (about 55 F), so outside heat not an issue. I assume this is a normal occurrence.
Rick
-
Originally Posted by Lew L
.
Not soon......... The shop I kinda trust is out 7 weeks for service. Vacation to Pikes Peak and three-wheel rally cancelled!! Oregon ryde with friends cancelled. V-Max is a great back up but not for cross country with my wife.
Bummer. Is there anything else you can check out in the meantime, like the water pump and sensor?
Any fluids underneath the bike? Probably not but thought I'd ask.
How many miles on the bike? Just curious.
2014 RTL Platinum
-
ENGINE OVERHEATING 1. Low coolant level. - Refill and check for leaks (coolant leaking out of engine leak indicator hole, hoses or clamps missing/defective, cylinder head gaskets leaks, ride plate leaking, etc.). Repair or replace. 2. Air in cooling system - Refill and bleed cooling system. - Check bleeding nozzles in water pump module and cylinder head if they are clogged. 3. Thermostat defective (does not open when engine gets hot) - Replace water pump module. 4. Water pump failure - Inspect water pump drive gears. - Inspect and replace defective components. 5. Water temperature sensor defective - Check or replace. Refer to ELECTRONIC FUEL INJECTION (EFI). 6. Radiator or hoses damaged - Check or replace damaged components. 7. Internal passage blocked in cooling system - Inspect and clean.
Took that out of the manual
Maybe Thermostat or pump or sensor??
Any codes?
-
Very Active Member
It sounds to me like the old fashioned thermostat is stuck being the mostly likely culprit.
2020 RTL SE6
Previously 2008 GS SM5 and 2014 RT SE6
-
Very Active Member
Finding sensor and pump
Originally Posted by trikermutha
ENGINE OVERHEATING 1. Low coolant level. - Refill and check for leaks (coolant leaking out of engine leak indicator hole, hoses or clamps missing/defective, cylinder head gaskets leaks, ride plate leaking, etc.). Repair or replace. 2. Air in cooling system - Refill and bleed cooling system. - Check bleeding nozzles in water pump module and cylinder head if they are clogged. 3. Thermostat defective (does not open when engine gets hot) - Replace water pump module. 4. Water pump failure - Inspect water pump drive gears. - Inspect and replace defective components. 5. Water temperature sensor defective - Check or replace. Refer to ELECTRONIC FUEL INJECTION (EFI). 6. Radiator or hoses damaged - Check or replace damaged components. 7. Internal passage blocked in cooling system - Inspect and clean.
Took that out of the manual
Maybe Thermostat or pump or sensor??
Any codes?
........ So....
No codes, no puddles, no leaking fluid. Poked around to try and find the sensor today. I'll raise her up and see if I can get at it from the bottom. I thought the thermostat was built into the water pump as one unit---- hopefully not. Can the water pump be replaced from the side????
Thanks all.
Lew L
Kaos----- Gone but not forgotten.
2014 RTS in Circuit Yellow, farkle-ing addiction down to once every few months. ECU FLASH IS GREAT.
-
Very Active Member
Originally Posted by Lew L
........ So....
No codes, no puddles, no leaking fluid. Poked around to try and find the sensor today. I'll raise her up and see if I can get at it from the bottom. I thought the thermostat was built into the water pump as one unit---- hopefully not. Can the water pump be replaced from the side????
Thanks all.
Lew L
Go on cheapcycle and look at the break down, you will get a idea of what your up to!! Good luck!
Tags for this Thread
Posting Permissions
- You may not post new threads
- You may not post replies
- You may not post attachments
- You may not edit your posts
-
Forum Rules
|