-
Spyderpops Air Management System
Haven't pulled the panel over the radiator yet, but it's not readily apparent how the system should be installed. Anyone have pics?
-
OK, it became abundantly clear when I removed the right panel covering the radiator. Although where it should go was clear, dry fitting and installation was extremely difficult because the material is very stiff (my stickiest duct tape could not hold it onto the factory air shoot). Since I didn't have a rivet gun, I used screws/lock washers/nuts instead of the provided rivets. I had to drill a couple of holes in addition to the predrilled ones because it wouldn't overlap the air shoot. Then, I simply installed it bit-by-bit, screw-by-screw, hoping that it would fit ok once I was done. Final product closed off all the spaces from the radiator leading back to my right leg except for above the top radiator hose. I don't know if hot air can even get by there but I stuffed some foam rubber in there anyway. Total time was about three hours but I took my time. Haven't tried it out yet. Will follow-up in a couple of days.
Air.jpg
-
OK, finally did a test run. The air management system and the missing air dam have resolved my hot right leg problem and lowered my temp gauge one bar in traffic and two bars on the freeway. BTW, I simply removed the floorboard on the right side as recommended elsewhere in this forum, rather than cutting/installing a small vent that came with the kit. Highly recommend, even though it's pricey for what you get.
-
Ozzie Ozzie Ozzie
-
Active Member
I have installed the same kit on my Spyder and have nothing but good to say about it. I did not, however, install the scoop nor did I remove the bottom panel which does not appear to make the bike run hotter. Despite that and riding in hot (and humid) temps, the kit has improved the riding experience. Welcome to the forum, by the way!
2010 Full Moon Silver RS SE5
-
Peter and Web Runner, Thanks for the kind words. I got my first Spyder with only about 400 miles on it but it had sat largely unused for many years. Lot's of cleaning up and problem solving, especially because there's no authorized dealer here. New experience, new excitement, new fun. This is a great forum.
-
Originally Posted by phily
haven't pulled the panel over the radiator yet, but it's not readily apparent how the system should be installed. Anyone have pics?
the "air management system" 2008-2012 gs/rs/rss only
spyderpops
sku: Spy104
$58.00
2014 RTL Platinum
-
Active Member
Thank you for posting this! I too am debating on the installation of all 3 of the products for relieving the hot air blast onto my right leg, and for lowering the driving temp.
-
Totally worth the money. I installed the set on my 2008 GS and it made a huge difference. Love it.
Posting Permissions
- You may not post new threads
- You may not post replies
- You may not post attachments
- You may not edit your posts
-
Forum Rules
|